Product ID:SETFAST PREMIUM TRAFFIC PAINT-YELLOW, A-301
MSDS Date:01/01/1987
FSC:8010
NIIN:00N008041
MSDS Number: BCPGK

BALTIMORE PAINT & CHEMICAL CO.,DIV SHERWIN-WILLIAM

1370 ONTARIO ST
CLEVELAND, OH 44113-1701
US

Cage: 85321

BALTIMORE PAINT DIV OF THE SHERWIN-WILLIAMS CO

CLEVELAND, OH 44113-1701 US

Cage: 85321

LEAD CHROMATE (OSHA PEL FOR LEAD FROM 29CFR

CAS: 7758-97-6

RTECS: GB2975000

Fraction By Weight: 7.59%

OSHA PEL 0.05 MG/M3 (PB)

ACGIH TLV: 0.05MG/M3(CR)A2;8990

ALIPHATIC HYDROCARBONS

Fraction By Weight: 20.7%

ACGIH TLV: 150 PPM (MFR)

AROMATIC HYDROCARBONS

Fraction By Weight: 5.02%

ACGIH TLV: 100 PPM (MFR)

METHYL ALCOHOL (METHANOL) (SARA III)

CAS: 67-56-1

RTECS: PC1400000

Fraction By Weight: 0.13%

OSHA PEL S,200PPM/250STEL

ACGIH TLV: S,200PPM/250STEL; 93

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Effects of Overexposure:EYE:SEVERE IRRIT.SKIN:DRYNESS.INHAL:POSS
ASPHYXIATION.PROLONG CONT POSS RESP ALLERGIC(SEE SUPP DATA)

First Aid:EYES: FLUSH IMMED W/PLENTY OF H*2O FOR @ LEAST 15 MIN.GET MED
ATTN. SKIN: REMOVE CONTAM CLOTHING,WASH AFFECTED AREA W/H*2O.CALL
PHYSICIAN. INHAL: REMOVE FROM EXP,RESTORE BREATHING,KEEP WARM &
QUIET.CA LL PHYSICIAN.

Flash Point:40F, 4.4C
Lower Limits:1.0
Extinguishing Media:NFPA CLASS B ENTINGUISHER
Fire Fighting Procedures:USE SCBA,FULL PROT EQUIP.H*20 SPRAY POSS (SEE
OTHER PRECAUT)
Unusual Fire/Explosion Hazard:KEEP CNTNRS CLSD TIGHT.ISOLATE FROM
IGNITION SOURCES.CLSD CNTNRS MAY EXPLO IF EXP TO (SEE SUPP DATA)

Spill Release Procedures:REMOVE ALL IGNITION SOURCES(FLAME,HOT SURFACES
& ELECTRICAL,STATIC/FRICTIONAL SPARKS).AVOID BREATHING
VAPORS.CONTAIN & REMOVE W/INERT ABSORBENT & NON-SPARKING TOOLS.

Handling and Storage Precautions:KEEP AWAY FROM SPARKS,OPEN FLM &
HEAT.DO NOT STORE ABOVE 120F.DONT INGEST.AVOID PRLNG SKIN CONT.USE
W/ADEQUATE VENT.GROUND CNTNRS WHEN POURING.
Other Precautions:SPECIAL FIRE FIGHT PROC:INEFFECTIVE.IF USE
H*2O,PREFER FOG NOZZLES.USE H*2O TO COOL CLSD CNTNRS,PVNT PRESS &
EXPLOSION.RESP PROT:RESTRICTED VENT AREA:NIOSH/MSHA APPRVD CHEM
MECH FILTER RSPTR.

Respiratory Protection:OPEN AREA:NIOSH/MSHA APPRVD MECH FILTER
RESPIRATOR(SEE OTHR PRECAUT)
Ventilation:POCKETS OF HEAVY &/OR FLAM VAP MUST NOT BE PERMITTED TO
FORM
Protective Gloves:LONG/RPTD CONT
Eye Protection:SPLASHPROOF SFTY EYEWEAR
Other Protective Equipment:PREVENT PROLONG SKIN CONT W/CONTAM CLOTHING.
Supplemental Safety and Health
OVEREXP EFTS: SENSITIVITY.EXCESSIVE EXP TO LEAD MAY CAUSE APPETITE
LOSS,INDEGESTION,NAUS,VOMIT,CONSTIPATION,ABDOMINAL CRAMPS &
WEAKNESS. FIRE HAZ: EXTREME HEAT.DONT APPLY TO HOT SURF.DOP:8/81.

Boiling Pt:B.P. Text:210-290F
Vapor Density:> 1
Spec Gravity:1.4447
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:49.8

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Conditions to Avoid Polymerization:ELEVATED TEMPERATURES.

Waste Disposal Methods:DISPOSE OF IAW FEDERAL,STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.